SmartLife Battery Packs Instructions for Use Rev C April 2012

EN

7215-001-700 Rev-C

Introduction

Indications For Use

This Instructions For Use manual is the most comprehensive source of information for the safe and effective use of your product. This manual may be used by in-service trainers, physicians, nurses, surgical technologists, and biomedical equipment technicians. Keep and consult this reference manual during the life of the product. The following conventions are used in this manual: • A WARNING highlights a safety-related issue. ALWAYS comply with this information to prevent patient and/or healthcare staff injury. • A CAUTION highlights a product reliability issue. ALWAYS comply with this information to prevent product damage. • A NOTE supplements and/or clarifies procedural information. If additional information or in-service training is required, contact your Stryker sales representative or call Stryker customer service. Outside the US, contact your nearest Stryker subsidiary.

See the instructions for use supplied with the handpiece.

2

Contraindications See the instructions for use supplied with the handpiece.

For Use With The battery pack is only intended for use with the following Stryker handpieces: DESCRIPTION

REF

System 7 Handpieces

720X-XXX-XXX series Charge the battery pack with one of the following Stryker battery chargers configured with a Stryker System 6 Charger Module (REF 6110-625-000): DESCRIPTION

REF

System 6 Battery Charger

6110-120-000

Universal Battery Charger

7110-120-000

www.stryker.com

7215-001-700 Rev-C

User/Patient Safety WARNINGS: • Before using any system component, or any component compatible with this system, read and understand the instructions. Pay particular attention to WARNING information. Become familiar with the system components prior to use. • Only trained and experienced healthcare professionals should use this equipment. • The healthcare professional performing any procedure is responsible for determining the appropriateness of this equipment and the specific technique used for each patient. Stryker, as a manufacturer, does not recommend surgical procedure or technique. • Upon initial receipt and before each use, clean and sterilize the equipment as indicated. See the Heavy Duty Care Instructions manual supplied with the handpiece for processing instructions.

www.stryker.com

EN

• Upon initial receipt and before each use, operate the equipment and inspect each component for damage. DO NOT use any equipment if damage is apparent. See the Heavy Duty Care Instructions manual supplied with the handpiece for inspection criteria. • Before use, ALWAYS allow the equipment to reach the operation temperature range specified in the instructions for use supplied with the handpiece. • To prevent the equipment from overheating, ALWAYS follow the recommended duty cycle specified in the instructions for use supplied with the handpiece. • Risk of Fire, Burns and Explosion. Do not Short Circuit, Open, Crush or Incinerate. Sterilize only per instructions. Consult instructions for use. • DO NOT allow the battery contacts to touch metal objects.

3

EN

7215-001-700 Rev-C

Features

A

Indicator Light – Provides status information for the battery pack: • The light will blink when the battery pack is near the end of its charge cycle. • The light will illuminate in a steady state for 10 seconds when the battery pack is expended.

B

Battery Contacts – Interlock with the handpiece to complete the electric circuit.

C

Battery Latch – Retains the battery pack in the handpiece.

C B A

4

www.stryker.com

7215-001-700 Rev-C

EN

Definitions

Instructions

The symbols located on the equipment and/ or labeling are defined in this section or in the Symbol Definition Chart. See the Symbol Definition Chart supplied with the equipment.

NOTES: • See the instructions for use supplied with the battery charger to properly charge the battery pack before each use. • For maximum capacity, charge the battery pack before sterilization, even if the battery pack has not been used. • A typical charging sequence will take between 5 and 30 minutes. Charging a fully expended large battery pack may take up to 75 minutes. • For maximum capacity, store the battery pack on the battery charger to maintain a full charge. DO NOT store the battery pack installed in a handpiece. Discharge will occur even though the handpiece is not operating. • Stryker recommends using battery packs that have been charged within the last 5 days.

SYMBOL

DEFINITION Battery Pack Status Consult instructions for use

Caution, consult accompanying documents General warning sign

Years of environmentally-friendly use, per China RoHS standard

www.stryker.com

5

EN

7215-001-700 Rev-C

Instructions (continued)

Sterilization

NOTES: • See the instructions for use supplied with the handpiece to properly install and remove the battery pack from the handpiece. • Typical battery pack run time is 20 minutes or longer, depending on surgical procedure or technique. • When the indicator light blinks, reducing the load on the handpiece may extend the usage time of the battery pack.

See the care instructions supplied with the handpiece.

Cleaning and Disinfection See the care instructions supplied with the handpiece.

Inspection and Testing See the care instructions supplied with the handpiece.

6

Storage and Handling See the care instructions supplied with the handpiece.

Disposal/Recycle See the care instructions supplied with the handpiece. Per Directive 2006/66/EC, collect and recycle batteries/battery packs according to EU Member State regulations. This rechargeable battery pack contains Lithium-Ion.

www.stryker.com

7215-001-700 Rev-C

EN

Specifications CAUTION: ALWAYS store the equipment within the specified environmental condition values throughout its useful life. NOTE: Specifications are approximate and may vary between devices. Model:

Stryker SmartLife Battery Pack, Small (REF 7212-000-000)

Type:

Rechargeable, Lithium-Ion Battery Pack

Dimensions:

58 mm [2.3 inch] height 71 mm [2.8 inch] width 84 mm [3.3 inch] length

76 mm [3.0 inch] height 71 mm [2.8 inch] width 84 mm [3.3 inch] length

Mass:

0.27 kg [0.6 lb]

0.41 kg [0.9 lb]

Electrical Output:

9.9 V

9.9 V

Capacity:

10.9 Wh

Mode of Operation:

See the mode of operation in the instructions for use supplied with the handpiece.

Ingress Protection:

IPX0 Ordinary Equipment

Environmental Conditions:

See the operation, storage, and transportation specifications in the instructions for use supplied with the handpiece.

www.stryker.com

(Direct current)

Stryker SmartLife Battery Pack, Large (REF 7215-000-000)

21.8 Wh

7

Stryker Instruments 4100 E. Milham Kalamazoo, Michigan (USA) 49001 1-269-323-7700 1-800-253-3210

Stryker France ZAC Satolas Green Pusignan Av. de Satolas Green 69881 MEYZIEU Cedex France 2012-04

7215-001-700 Rev-C

www.stryker.com